![]() They were just an affordable option for Ezgo to make and give away with new carts. Those are not the highest quality chargers available. If you do get the same voltage then we would begin to think the charger may be on the fritz. A problem with corrosion or heat generation or even vibration could loosen a connection. ![]() If not, then that tells us there is a break or resistance in the charge circuit somewhere. ![]() You should have the same voltage there as on the batteries. We would think 35 volts is still well within the limits of that charger to turn itself on…thinking those Delta Q QE Golf Cart Battery Chargers required approximately 30 volts to activate the relay.Ĭheck the voltage with a digital volt meter at the battery bank and then do so at the golf cart battery charger receptacle on the cart where you plug charger into charge. The battery voltage fault light will activate when the golf cart batteries are too low or too high. Pete\’s team is always standing by to help you. Should you have any questions about your golf cart battery charger or determine that you need to purchase a new one, feel free to contact usand speak with one of Battery Pete\’s team members. If you find this article helpful please reply to this article post below. ![]() Need a OEM replacement for your old charger? If fault 6 is again displayed after unplugging and then plugging in the DC power cord, the charger will need to be replaced or should be brought into a qualified service center. Reconnect Ac power first then DC connector to golf cart. Wait a few minutes (10 minutes) to be sure. Try to disconnect AC and DC connectors from cart and wall socket. It indicates a problem with the battery bank voltage not attaining the required nominal voltage level required to shut the charger off within the maximum time allowed.Ħ.) Six Red Flashes = Charger Fault: Detects an internal fault. This means the charge time exceeded the safe parameters and operation of battery charger set by the golf cart battery charger manufacturer. Charger output current severely reduced due to excessive length of electric extension cord used to reach AC power source or high ambient temperatures.ĥ.) Four Red Flashes = Battery Charger Timeout. In this case you might need to replace batteries.Ĭ. The batteries are old (sulfation/build-up on lead plates does not allow amperage and voltage to pass thru freely causing excessive resistance, generating heat. The Battery bank is severely depleted over 50% D.O.D. This could be any combination of things:Ī. See my article – How to get your golf cart battery charger to charge dead batteries.Ĥ.) Three Red Flashes = Battery Charger Timeout. It is usually because the battery bank voltage is too low and the battery charger does not sense enough voltage to kick on and start to apply voltage and amperage. If the golf cart\’s battery bank is less than 36.0 volts or more than 67.2 volts you may get this fault. This results from too much voltage or not enough. Battery Temperature could be greater than 122 degrees Fahrenheit or 50 degrees Celsius.ģ.) Two Red Flashes = Battery Voltage Fault. Might also be a battery temperature issue or fault. Check the plug position in the cart side receptacle to ensure good contact. Check for poor contact in the DC side connector. Check for valid AC power going to the golf cart battery charger.Ģ.) One Red Flash = Charge Enabled Fault. Fault Code Informationġ.) Red Flash – Light comes on briefly but nothing after that. Examplesġ.) A Short Green Flash = The golf cart charge status is less than 80%.Ģ.) A Long Green Flash = The golf cart charge status is more than 80%.ģ.) Solid Green = The golf cart charge status is 100%.Ĥ.) Red Flash = Fault Code. The Delta Q QE EZGO golf cart battery charger flashing LED charge indicator lights communicate several different degrees of charger status during the charge cycle. The LED display is a great visual representation for charger status at a glance. We will go into some specifics here to cover what each light color represents and any combination of colors flashing together. We frequently get calls about the flashing LED indicator lights on the OEM Ezgo golf cart battery charger by Delta Q Technologies.
0 Comments
Leave a Reply. |
AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |